The study, conducted at the El-Nubaria Agricultural Research Station in Beheira Governorate, was designed around a soybean–faba bean rotation typical of Egypt’s expanding agricultural frontier. Soybean (cv. Giza 111) was sown in June 2024 and faba bean (cv. Giza 716) in November 2024, on a sandy clay loam soil with a pH between 8.04 and 8.19 and a calcium carbonate content exceeding 25 percent. Such soils are notoriously hostile to crops: the alkaline chemistry drives phosphorus, iron, and zinc into insoluble forms, while the fragile surface crusts easily and organic matter is scarce. When water deficit is layered on top, nutrient movement toward roots slows further, compounding the stress.

The researchers, led by Dalal Hereimas Sary of Egypt’s Soils, Water and Environment Research Institute together with colleagues including Ozkan Kaya and Harlene Hatterman-Valenti of North Dakota State University, set up a split-plot experiment with two irrigation regimes — full irrigation at 100 percent of crop evapotranspiration (ETc) and deficit irrigation at 75 percent ETc — crossed with seven treatments. These were an untreated control; sugar beet residue incorporated into the soil at 12 and 24 tonnes per hectare; foliar sprays of molybdenum trioxide nanoparticles (n-MoO₃) at 200 and 400 milligrams per liter; and foliar sprays of the amino acid L-proline at the same two concentrations. The nanoparticles averaged roughly 10 nanometers in diameter, while the sugar beet residue, collected from the El-Nubaria Sugar Company, proved remarkably rich: 83 percent organic matter, 1.8 percent nitrogen, 2.0 percent potassium, and a balanced carbon-to-nitrogen ratio of 27:1.

The yield results were unambiguous and remarkably stable across both crops. Sugar beet residue at 24 tonnes per hectare (SB₂₄) ranked first in every case, followed by the 12-tonne rate, then the high-dose nanoparticles, high-dose proline, and the low-dose versions of each, with the untreated control trailing last. Under full irrigation, SB₂₄ lifted faba bean plant dry weight, seed yield, and 100-seed weight to 9.63 kilograms per plot, 3.27 kilograms per plot, and 100.50 grams respectively — 88 percent, 146 percent, and 12 percent above the corresponding controls. In soybean, the same treatment produced the highest seed yield of 2.66 kilograms per plot and the highest oil content measured in the study, 21.45 percent.

The physiological data revealed why the treatments behaved so differently. Foliar molybdenum nanoparticles dominated one narrow axis: they raised leaf molybdenum concentrations dramatically, by roughly 89 percent in soybean compared with the deficit-irrigated control, and nearly doubled seed molybdenum. This matters because molybdenum is a rate-limiting cofactor for nitrate reductase and nitrogenase, the enzymes at the heart of nitrogen assimilation and biological nitrogen fixation in legumes. Delivering it as a nanoscale oxide through the leaf surface proved an efficient route into the harvested seed. Proline sprays, meanwhile, peaked on their own axis: leaf proline reached its maximum under the high-dose proline treatment at 75 percent ETc, hitting 48.55 micrograms per gram in soybean, about 16 percent above the control, consistent with proline’s well-documented role in osmotic adjustment and membrane stabilization under drought.

Sugar beet residue operated on an entirely different and broader front. Rather than targeting a single micronutrient or osmolyte, the organic amendment reshaped the rhizosphere, raising leaf and seed concentrations of nitrogen, phosphorus, and potassium simultaneously in both crops. Leaf potassium in faba bean reached 1.58 percent under SB₂₄ at full irrigation, and seed nitrogen in soybean climbed to 6.25 percent. The authors interpret this as rhizosphere-mediated action: the residue’s organic matter and cation-exchange-active functional groups progressively improve nutrient availability and uptake dynamics, in contrast to the foliar absorption pathway exploited by the nanoparticle sprays.

One of the study’s most intriguing findings is a counterintuitive biochemical signature. Ascorbic acid, a key non-enzymatic antioxidant, was highest in untreated, deficit-irrigated plants — 23.14 milligrams per liter in soybean — and declined progressively under the most effective treatments, falling to 16.31 milligrams per liter under high-dose proline at full irrigation. Rather than indicating weakened antioxidant defenses, the authors argue this decline signals stress relief: when a treatment successfully mitigates water stress, the plant no longer needs to deploy its full antioxidant arsenal, and freed metabolic resources are channeled into growth and yield. A negative correlation between leaf proline and seed yield in faba bean (r = –0.64) reinforced this interpretation, and principal component analysis placed the antioxidant pair at the opposite end of the productivity axis from yield traits.

Water productivity — the kilograms of seed produced per cubic meter of irrigation water — told perhaps the most consequential story. The SB₂₄ treatment combined with 75 percent ETc achieved the highest values in both crops: 0.56 kilograms per cubic meter in faba bean and 0.32 in soybean, which were 3.7-fold and 4.6-fold higher than the untreated controls under the same deficit regime. Because the deficit regime applied 4,742 cubic meters per hectare to faba bean and 6,507 to soybean, compared with 6,323 and 8,676 under full irrigation, pairing the organic amendment with a 25 percent water cut allowed the crops to squeeze dramatically more output from every drop. Notably, the SB₂₄ deficit combination matched or exceeded several full-irrigation treatments for seed nitrogen, phosphorus, and potassium, suggesting the amendment can partially compensate for a moderate reduction in water supply.

The economics sealed the case. Under full irrigation, SB₂₄ generated the highest returns in both crops: a gross income of US$2,302.22 per hectare and a benefit-to-cost ratio of 3.53 in faba bean, and US$1,418.44 per hectare with a ratio of 2.32 in soybean. Under deficit irrigation, SB₂₄ still delivered strong ratios of 2.93 and 1.84 respectively, while conserving roughly 1,600 to 2,200 cubic meters of water per hectare. The contrast with the control was stark: untreated soybean under deficit irrigation was the only combination to lose money, posting a net loss of US$115.42 per hectare. In soybean, only the two residue rates and high-dose proline cleared the break-even threshold under full irrigation, and only SB₂₄ did so under deficit irrigation.

The authors are careful to acknowledge the limits of their evidence. The proposed mechanisms — improved soil water retention, aggregate stability, and modified microbial activity — were inferred rather than directly measured, since the study did not characterize the soil water characteristic curve, hydraulic conductivity, bulk density, or microbial activity, and leaf gas exchange and water potential were likewise not assessed. The trial also spanned a single site and one rotational cycle. Still, the convergence of nutritional, physiological, multivariate, and economic data on a single conclusion is compelling: for water-limited legume production on calcareous soils, a low-cost industrial residue can outperform sophisticated nano-fertilizers and biostimulants, and the choice between applying it with full or reduced irrigation comes down to whether water or land is the scarcer resource on a given farm. As Egypt and other arid nations push agriculture into marginal soils, the most powerful tool on the field may be the one the sugar factory throws away.

Subject of Research: Sugar beet residue, nano-MoO₃, and proline as stress-mitigating amendments for deficit-irrigated soybean and faba bean on calcareous soil

Article Title: Sugar beet residue outperforms foliar nano-MoO₃ and proline under deficit irrigation in a soybean–faba bean rotation on calcareous soil

Article References: Sary, D. H., Emam, A. A. E., El-Nagar, D. A., Mahmoud, M. A., Kaya, O., & Hatterman-Valenti, H. (2026). Sugar beet residue outperforms foliar nano-MoO₃ and proline under deficit irrigation in a soybean–faba bean rotation on calcareous soil. Plant and Soil. https://doi.org/10.1007/s11104-026-08974-x

Image Credits: AI Generated

DOI: 10.1007/s11104-026-08974-x

Keywords: sugar beet residue, deficit irrigation, calcareous soil, soybean, faba bean, molybdenum nanoparticles, proline, water productivity, soil amendment, legume rotation, Egypt, benefit-cost ratio